[Sohcahtoa82]

In theory, a PHEV is the perfect middle ground for someone that wants to drive electric but has major range anxiety about road trips.

Something with a 60 mile electric range will likely satisfy all of their day-to-day driving. The generator means they don't have to charge though, so they can still take road trips without worrying about electric range.

In practice though, they're somewhat impractical. You still need an entire ICE drivetrain AND a moderately sized battery and electric motor, driving the price up.

[loudmax]

My Prius Prime PHEV has a range of about 25 miles on battery. My daily commute to work is about 10 miles each way, so I can get to work and back on electric alone. If I happen to need to make a longer trip, then my car switches to gas. I plug in the car when I get home from work and I only need to refill the tank every few months. And even then, it's extremely fuel efficient because it's still a Prius.

This has been a perfect car for my use case, but the big caveat is my short commute. If your daily commute fits inside that short range (or one way commute if there's a charger at your workplace), this can be a great fit. A+++, highly recommended.

If your work commute is significantly longer than a PHEV's battery range, or if you don't have a convenient place to charge it, then it's a much less attractive proposition.

[mschild]

Not only somewhat impractical.

Most people don't end up charging their battery because it still has an ICE so why bother? So now they have the worst of both worlds. Complex ICE machinery that needs regular service and heavy battery that doesn't end up being used.

[londons_explore]

Still gives decent efficiency improvements. You can always run the ICE at most efficient RPM. Never need to idle it, etc.

You can also have a much smaller engine for a much bigger car, since you only need to cover average not peak power usage.

You also in most designs eliminate the gearbox.

[mrob]

Only true for a plug-in hybrid with a series drivechain (a.k.a. "extended range electric vehicle"). The more common type has two parallel drivechains linked with clutches, so you still have all the drawbacks of a conventional internal combustion engine drivechain when you're using it.

[tzs]

> The more common type has two parallel drivechains linked with clutches, so you still have all the drawbacks of a conventional internal combustion engine drivechain when you're using it

I don't know about the whole world, but in both the US and Europe nearly half of the hybrids on the road are from Toyota, so unless nearly everything else is two parallel drive chains linked with clutches whatever Toyota does is the more common type.

Toyota uses a series-parallel system that works by having a planetary gear system that connects the ICE, a large electric motor, a small electric motor, and a drive shaft all together.

The planetary gear system functions as a power splitting device and a continuously variable transmission. It lets them direct power flow in a bunch of different ways. Here's a summary based on Wikipedia. (MB == the bigger battery, 12V == the regular 12V batter, ICE == the ICE engine, MG1 == the smaller electric motor, MG2 == the larger electric motor):

• Aux power: MB -> DC/DC converter -> 12V

• Charge: ICE -> MG1 -> MB

• EV drive: MB -> MG2 -> wheels

• Moderate acceleration: ICE -> wheels, ICE -> MG1 -> MG2 -> wheels

• Highway: ICE -> wheels, ICE -> MG1 -> MB

• Heavy power, such as on steep hills: ICE -> wheels, ICE -> MG1 -> MB, ICE -> MG1 -> MG2 -> wheels

• Max power: ICE -> wheels, ICE -> MG1 -> MG2 -> wheels, MB -> MG2 -> wheels

• Regenerative braking: wheels -> MG2 -> MB

• B-mode braking: Wheels -> MG2 -> MB, Wheels -> MG1 -> ICE

This is a big part of why Toyota hybrids are at the top of reliability rankings. Compared to a pure ICE they replace the clutch, the transmission, the starter motor, the alternator, the reverse gear set, and the flywheel with the planetary gear power splitting device. the two electric motors, and electronics. The power splitting device has very few movings parts--just the gears themselves, a pawl that can mechanically lock the gears when parked, and fluid pumps. The gears only move by rotating, unlike in a conventional transmission where they also change position. This makes their hybrids mechanically much simpler than a pure ICE.

[appointment]

This is something people say, but in practice the Toyota Prius is still a very reliable car.

[mschild]

If you charge the battery, sure. Most people simply don't.

Data collected across 600.000 vehicles in Europe show that most people don't and that emissions are just a smidge under typical ICE vehicles. If you factor in the high emissions produced during battery productions it looks to be an overall bad package.

The idea itself is certainly good but the real world simply doesn't show it.

https://www.evshift.com/368695/do-people-actually-charge-the...

[fragmede]

You have to factor in regerative braking. Toyota's had ~25 years to get their system dialed in. Hybrid is worth it unless you're only ever doing freeway speeds flat out with no braking.

[londons_explore]

As a Toyota hybrid owner, you see that Toyota's design is kinda at a local optimum, hitting limits in every direction which sometimes rear their head in the user experience.

For example, the sluggish 0-60 is due to the design being unable to get all the power from the engine to the wheels at slow speeds, due to the electrical path through the CVT gearbox being too small.

The funny noises when going down really big hills are due to the system having no way to dump excess energy after the battery is fully charged and being forced to rev the engine at 5000 rpm with no fuel to waste some.

The slow throttle response is due to the engine always running at 80% throttle for efficiency, which means if you suddenly need more power you can only quickly get an additional 20% before waiting for the rpm to slowly rise and give lots of power in a few seconds.

EV's do have similar design limitations (drive on a racetrack and you'll need to let the hardware cool between laps), but they seem easier to overcome by simply sizing the system slightly bigger to hide the limits.

[fragmede]

You make valid points, but to get almost 40 mpg in something that would get closer to 20 mpg without the hybrid system, there are gonna be some drawbacks.

[hgomersall]

Small batteries mean heavy cycling of those batteries. When on pure EV, the oversized battery means most days you sit in the middle third of the battery which is great for battery longevity.